Re: [Amc-list] 232 intake manifold gasket

[Wrambler242@xxxxxxxxxxx]

Some will say use them both, some will say don't.
I don't, but that being said since it allready had one in place you may want to use one.
I'd clean the surface and straight edge it. If it is true and straight I would not use the gasket.
  If it is not straight I would take to a machine shop and have it surfaced. Then I would not use the gasket.
To my thinking the engine was made and  delivered without the gasket, if the metal to metal seal is mooth and flush the gasket is not needed and won't be there to burn out.
   I have actually succesfully installed cast exhaust manifolds on engines that came with gaskets usin g this method!
However, If you have the gasket and surfaces are questionable then use it.
   Be sure to toque it properly, run it till hot, then retorque. Drive it a few cycles of heat cool, checking the torque as often as you can without going insane until you are sure it is staying torqued.
   You should get many miles out of it if you take the time to do it right, with or without the gasket!

--
Mark Price
Morgantown, WV
1969 AMC Rambler, 4.0L, EFI, T-5
2004 Grand Cherokee Laredo, 4.7L, Quadratrc II
" Chronic Pain Hurts"

 -------------- Original message ----------------------
From: "Thomas Garner" <Tgarner@xxxxxxxxxxxxxx>
> I bought the intake/exhaust gasket set for my 232. It had to gasket's for the 
> intake, one with and without the exhaust gasket. I think I was told that this 
> engine didn't use an exhaust gasket. 
> 
> Ok, I took the intake and exhaust manifold off of my engine and discovered that 
> somebody had put BOTH gaskets on. The small blue one for the intake AND the big 
> long silver one for the intake and exhaust.
>  That's not right is it?
> 
>  
> FREE SATELLITE DISH AND INSTALL!!
> http://www.bestofdishnetwork.com/
> 
> 
> _____________________________________________________________
> Are you prepared for your exam
> 4TestsMail - Free email you can access from anywhere!
> http://www.4testsmail.com/
> _______________________________________________
> Amc-list mailing list
> Amc-list@xxxxxxxxxxxx
> http://splatter.wps.com/cgi-bin/mailman/listinfo/amc-list

_______________________________________________
Amc-list mailing list
Amc-list@xxxxxxxxxxxx
http://splatter.wps.com/cgi-bin/mailman/listinfo/amc-list