Re: [AMC-list] windshield removal

[wrambler242@xxxxxxxxxxx]

One more tip. 
Tape the gasket/seal to the glass and leave it in place till ready to install. Protects the glass during storage. 
Sent from my BlackBerry® wireless device from U.S. Cellular

-----Original Message-----
From: wrambler242@xxxxxxxxxxx
Date: Tue, 8 Jun 2010 01:24:11 
To: AMC, Rambler, Nash, Jeep and family<amc-list@xxxxxxxxxxxx>
Subject: Re: [AMC-list] windshield removal

Yep.   
You want be very careful of the edges. Once chipped the glass will crack at that point. 
   My cars all have seals. I get a new seal. Then just cut the rubber where it wraps around the pinch weld on the inside. You only need to cut off the top and sides. Lay a blanket on the hood to protect the GLASS and hood if you care. 
    Then generally all you have to do is gently push the top of the windshield out and over, best done with a helper, but I have 5 pieces of front and rear glass I have done by myself in the shed. 
Sent from my BlackBerry® wireless device from U.S. Cellular

-----Original Message-----
From: russ hathaway <russh97309@xxxxxxxxx>
Date: Mon, 7 Jun 2010 16:46:06 
To: Rambler Nash Jeep and familyAMC<amc-list@xxxxxxxxxxxx>
Subject: Re: [AMC-list] windshield removal

I've taken out dozens of windshields, only cracked two.
I use the windshield knife but also have wire to use. I've used both with similiar results. I cut away as much of the seal, on older cars, or the butyl tape, on the newer ones, as I can with a razor knife or linoleum knife. Remove as much of the trim, inside visors and mirrors, etc., as you can. You don't want to be fighting things that will get in your way.
After removing everything see if it will come out by itself. I have had some that were barely held in place, they were so old.
I would not try it alone, as it is too easy to tweek and crack.
Take your time, don't do it in the blazing sun, and cut the butyl slowly.
If its a seal you can just cut away at anything showing....Russ


      
_______________________________________________
AMC-list mailing list
AMC-list@xxxxxxxxxxxx
http://list.amc-list.com/listinfo.cgi/amc-list-amc-list.com
_______________________________________________
AMC-list mailing list
AMC-list@xxxxxxxxxxxx
http://list.amc-list.com/listinfo.cgi/amc-list-amc-list.com
_______________________________________________
AMC-list mailing list
AMC-list@xxxxxxxxxxxx
http://list.amc-list.com/listinfo.cgi/amc-list-amc-list.com